Check and replace throttle valve potentiometer: Function and fault diagnosis

The throttle valve potentiometer informs the engine control unit about the opening angle of the throttle valve. The signal from this sensor is required to calculate the injection quantity, for example. This page explains the design and function of the throttle valve potentiometer. We will also show you which symptoms could indicate a fault in the sensor and how it can be checked in the workshop with simple means.

Important safety note

The following technical information and practical tips have been compiled by HELLA in order to provide professional support to vehicle workshops in their day-to-day work. The information provided on this website is intended for suitably qualified personnel only.

1. Functional principle

How the throttle potentiometer works

The throttle valve potentiometer determines the opening angle of the throttle valve. This information is then forwarded to the control unit and used as a parameter for calculating the necessary fuel quantity. It is mounted directly on the throttle valve shaft.

The throttle valve potentiometer is an angle transmitter with a linear characteristic curve. It converts the respective throttle valve opening angle into a proportional voltage ratio. When the throttle valve is actuated, a rotor connected to the throttle valve shaft slides over resistance tracks with its sliding contacts, which converts the throttle valve position into a voltage ratio.

2. Symptoms

Throttle potentiometer faulty

A defective throttle valve potentiometer can manifest itself as follows:

  • Engine jolts and/or splutters
  • Engine accelerates poorly
  • Poor starting behaviour
  • Increased fuel consumption
3. Cause of failure

Causes of a faulty throttle potentiometer

Causes of throttle valve potentiometer failure can be:

  • Contact fault at the plug connection
  • Internal short circuits caused by contamination (humidity, oil)
  • Mechanical damage
4. Troubleshooting

Checking the throttle potentiometer

The following test steps should be considered during troubleshooting:

1

Check the throttle valve potentiometer

Check the throttle valve potentiometer for damage

2

Check the plug connection

Check the plug connection to ensure it is fitted correctly and for any contamination

3

Measure the resistance

Measure the resistance at the throttle valve potentiometer ( circuit diagram required for pin assignment). Connect the ohmmeter and check the resistance with the throttle valve closed; slowly open the throttle valve and monitor the change in the resistance (an interruption to the sliding contact can be identified during the measurement). Check the resistance with the throttle valve fully open (observe the manufacturer's specifications).

4

Check the cable connections

Check the cable connections to the control unit for continuity and a short circuit to frame (circuit diagram required for pin assignment). Check the continuity of the individual cables with removed control unit plug and component plug; reference value approx. 0 ohms. Also check each cable against vehicle ground for a short circuit to frame; reference value approx. >30 MOhm.

Mennyire hasznosnak találod ezt a cikket?

Egyáltalán nem segít
5
4
3
2
1
Nagyon hasznos
Siker

Helytelen Captcha

Helytelen Captcha

Hiba

Something went wrong

Pótalkatrész-kereső
Jármű kézi azonosítása OE-szám
A legjelentősebb gyártók
Egyéb gyártók
Járműsorozatok Vissza
Jármű Vissza

Írja be az OE-számot a beviteli mezőbe. Az OE-számot általában magán a pótalkatrészen vagy a jármű dokumentumaiban találja meg.

Pótalkatrész-kereső
Egyszerű járműazonosítás a KBA-szám alapján Határozza meg az eredeti alkatrészszámmal rendelkező pótalkatrészeket is Részletes termékinformációk Keressen nagykereskedőket a közelében
dummy
Processing Selected Car
Gyártó
Járműsorozatok
Jármű
Motor teljesítménye
Motor hengerűrtartalma
Üzemanyag-típus
Építés éve
Motor kódja

Válasszon kategóriát:
Vissza
dummy
Megosztás
Küldés a következőn keresztül Link másolása
Az URL-cím átmásolva a clickboardra!
Cikkszám
Number
A cikkszám lemásolták!
Keresés az interneten Szerelési útmutató
További részletek
Neve Érték
Kevesebb részlet

A kereskedője
Autoteile Krammer GmbH
dummy
Lechstraße 1-3
68199 Mannheim
Termékprospektus letöltése

Egy gyors kérdés

Great! Just one more Step

Subscription successful

Head to your inbox and confirm your email address so that you don’t miss our updates!

Get ready for brand new technical videos, car repair advice, trainings, helpful diagnostic tips, marketing campaigns and much more... delivered straight to your inbox every two weeks!